PubMed · 8598750
The source did not provide an abstract. Follow the original record for more information.
Explore connections, maps & timelines
J G Collee. 1996-04-06. A dreadful challenge.. https://doi.org/10.1016/s0140-6736(96)91408-7
Cite the original work for its findings. Save a collection to share your selection of sources.
KEEP EXPLORING
Cotton gin trash (CGT) in the raw form is poorly digested by ruminants due to lignocellulosic complexes. These structures must be broken down before adequate digestion can occur. This may be performed by physical and/or chemical means. Two methods for improving digestibility are particle size reduction and/or treatment with sodium hydroxide (NaOH). To evaluate the effectiveness of each method, three experiments were performed in which different CGT types were tested. Each type represented trash from a particular cleaning stage in the cotton ginning process. First, each type was ground with a knife-type grinding mill using screen sizes 0.5, 1.0, and 2.0 mm. For the second experiment, particle size was held constant at 2 mm, and all CGT types were treated with 4% and 6% NaOH (w/w) at room temperature. An agitation cycle of 5 min on and 10 min off was used, with the total mixing time being 4 h. Lastly, particle size and NaOH concentration were held constant, and treatments were performed at room temperature, 40 degrees C, and 50 degrees C. The total mixing times were 2 and 3 h for 50 and 40 degrees C, respectively. For all experiments two subsamples of each treatment were tested for in vitro dry matter digestibility (IVDMD). From grinding alone, digestibility increased as particle size decreased. Grinding to 0.5 mm resulted in an average IVDMD of 47.8% while grinding to 2.0 mm resulted in an average IVDMD of only 33.8%. Digestibility also improved with a greater NaOH concentration. An average in vitro digestibility of 70.5% was achieved with 6% NaOH (w/w) treatment, essentially doubling that of the raw CGT. Increasing the reaction temperature did not result in increased digestibility because the mixture dried out, with a consequent reduction in chemical distribution and uniformity in heat transfer. There are still chemical residues in the CGT, and elimination/reduction of these is an issue that needs to be addressed in further research.
Recirculating aquaculture systems are highly intensive culture systems that actively filter and reuse water, thus minimizing water requirements and creating relatively small volumes of concentrated waste (compared to flow-through aquaculture systems). Vermicomposting, which uses earthworms to stabilize and transform organic wastes into valuable end-products, has been proposed as an alternative treatment technology for high-moisture-content organic wastes from agricultural, industrial and municipal sources. This study was conducted to determine if the effluent solids from a large recirculating aquaculture facility (Blue Ridge Aquaculture, Martinsville, Virginia) were suitable for vermicomposting using the earthworm Eisenia fetida. In two separate experiments, worms were fed mixtures of solids removed from aquaculture effluent (sludge) and shredded. Mixtures containing 0%, 5%, 10%, 15%, 20%, 25%, and 50% aquaculture sludge (dry weight basis) were fed to the worms over a 12-week period and their growth (biomass) was measured. Worm mortality, which occurred only in the first experiment, was not influenced by feedstock sludge concentration. In both experiments worm growth rates tended to increase with increasing sludge concentration, with the highest growth rate occurring with feedstocks containing 50% aquaculture sludge. Effluent solids from recirculating aquaculture systems mixed with shredded cardboard appear to be suitable feedstocks for vermicomposting.
Attempts were made to overcome too-low reproductive output in the 48-h short-chronic microbiotest with the rotifer Brachionus calyciflorus fed with microalgae (Pseudokirchneriella subcapitata) from algal beads older than 4 months (Chemosphere 50 (2002a) 365). Prefeeding of freshly hatched rotifers prior to the start of the actual growth experiments resulted in a satisfactory reproduction (i.e., an intrinsic growth rate r > 0.65), even with subsequent feeding of the rotifers with microalgae from beads stored up to 1 year. Rotirich is an attractive alternative inert food compared with the mixture of microalgae and Spirulina, originally used to prefeed the rotifers. When the rotifers were prefed for 2 h with 30 microg/mL Rotirich, it was then not necessary to add Spirulina to the microalgal food from beads. The above findings are a substantial simplification of the testing procedure of the new short-chronic "culture/maintenance-free" Rotoxkit microbiotest.